Efficient production of secretory Streptomyces clavuligerus β-lactamase inhibitory protein (BLIP) in Pichia pastoris

AMB Express, Apr 2018

β-Lactamase inhibitory protein (BLIP), a low molecular weight protein from Streptomyces clavuligerus, has a wide range of potential applications in the fields of biotechnology and pharmaceutical industry because of its tight interaction with and potent inhibition on clinically important class A β-lactamases. To meet the demands for considerable amount of highly pure BLIP, this study aimed at developing an efficient expression system in eukaryotic Pichia pastoris (a methylotrophic yeast) for production of BLIP. With methanol induction, recombinant BLIP was overexpressed in P. pastoris X-33 and secreted into the culture medium. A high yield of ~ 300 mg/L culture secretory BLIP recovered from the culture supernatant without purification was found to be > 90% purity. The recombinant BLIP was fully active and showed an inhibition constant (Ki) for TEM-1 β-lactamase (0.55 ± 0.07 nM) comparable to that of the native S. clavuligerus-expressed BLIP (0.5 nM). Yeast-produced BLIP in combination with ampicillin effectively inhibited the growth of β-lactamase-producing Gram-positive Bacillus. Our approach of expressing secretory BLIP in P. pastoris gave 71- to 1200-fold more BLIP with high purity than the other conventional methods, allowing efficient production of large amount of highly pure BLIP, which merits fundamental science studies, drug development and biotechnological applications.

A PDF file should load here. If you do not see its contents the file may be temporarily unavailable at the journal website or you do not have a PDF plug-in installed and enabled in your browser.

Alternatively, you can download the file locally and open with any standalone PDF reader:

https://link.springer.com/content/pdf/10.1186%2Fs13568-018-0586-3.pdf

Efficient production of secretory Streptomyces clavuligerus β-lactamase inhibitory protein (BLIP) in Pichia pastoris

Law et al. AMB Expr Efficient production of secretory Streptomyces clavuligerus β-lactamase inhibitory protein (BLIP) in Pichia pastoris Kin‑Ho Law 0 ManW‑ah Tsang 0 Yuk‑Ki Wong 0 Ming‑San Tsang 0 PuiY‑ee Lau 0 KwokY‑in Wong 0 Kwok‑Ping Ho kwok‑ 0 Yun‑Chung Leung yun‑ 0 0 Department of Applied Biology and Chemical Technology and the State Key Laboratory of Chirosciences, The Hong Kong Polytechnic University , Hung Hom, Kowloon, Hong Kong , China β‑ Lactamase inhibitory protein (BLIP), a low molecular weight protein from Streptomyces clavuligerus, has a wide range of potential applications in the fields of biotechnology and pharmaceutical industry because of its tight interaction with and potent inhibition on clinically important class A β‑ lactamases. To meet the demands for considerable amount of highly pure BLIP, this study aimed at developing an efficient expression system in eukaryotic Pichia pastoris (a methylotrophic yeast) for production of BLIP. With methanol induction, recombinant BLIP was overexpressed in P. pastoris X‑ 33 and secreted into the culture medium. A high yield of ~ 300 mg/L culture secretory BLIP recovered from the culture supernatant without purification was found to be > 90% purity. The recombinant BLIP was fully active and showed an inhibition constant (Ki) for TEM‑ 1 β‑ lactamase (0.55 ± 0.07 nM) comparable to that of the native S. clavuligerus‑ expressed BLIP (0.5 nM). Yeast‑ produced BLIP in combination with ampicillin effectively inhibited the growth of β‑ lactamase‑ producing Gram‑ positive Bacillus. Our approach of expressing secretory BLIP in P. pastoris gave 71‑ to 1200‑ fold more BLIP with high purity than the other conventional methods, allowing efficient production of large amount of highly pure BLIP, which merits fundamental science studies, drug development and biotechnological applications. β‑ Lactamase inhibitor; β‑ Lactamase inhibitory protein; Pichia pastoris; Recombinant protein expression; Secretory protein expression - Introduction β-Lactamase inhibitory protein (BLIP) is a low molecular weight protein (~ 17.5  kDa) naturally secreted by gram-positive bacterium Streptomyces clavuligerus (Doran et  al. 1990) . As its name suggests, BLIP can inhibit β-lactamases, which are bacterial enzymes that can hydrolyze β-lactam antibiotics, leading to bacterial resistance against these antibiotics. The inhibition mechanism is based upon the non-covalent competitive binding of BLIP to β-lactamases. The concave-shaped BLIP embraces β-lactamase by inserting its β hairpin loops into the active site of β-lactamase, completely masking β-lactamase’s active site from binding and hydrolyzing the β-lactam substrates (Strynadka et  al. 1996) . BLIP shows differential binding affinity to and inhibitory effect on different β-lactamases (Strynadka et  al. 1994) . It generally demonstrates specificity toward class A β-lactamases, inactivating them with inhibition constant (Ki) ranged from picomolar to micromolar (Doran et al. 1990; Rudgers et al. 2001; Zhang and Palzkill 2003; Yuan et al. 2011) . In particular, it shows a potent inhibition against the clinically important TEM-1 β-lactamase with a Ki of 0.1–0.6 nM (Strynadka et al. 1994; Petrosino et  al. 1999; Rudgers et  al. 2001) . On the contrary, BLIP does not inhibit class B, C and D β-lactamases (Strynadka et al. 1994). Because of the nanomolar-affinity interaction between BLIP and TEM-1 β-lactamase and the potent inhibitory effect of BLIP on TEM-1 enzyme, BLIP has found its implications in various aspects. First, from the point of view of biophysics, the potent interaction between BLIP and TEM-1 β-lactamase makes BLIP an appealing study model for protein–protein interaction. Determinants for the strong binding of BLIP with TEM-1 β-lactamase have been extensively characterized to elucidate the general principles of affinity and specificity in protein–protein interaction (Strynadka et al. 1996; Selzer et al. 2000; Zhang and Palzkill 2003; Kozer et  al. 2007; Wang et  al. 2007; Cohen-Khait and Schreiber 2016) . Second, BLIP has its therapeutic value as a proteinaceous β-lactamase inhibitor. Because of the susceptibility of β-lactam antibiotics toward the degradation by β-lactamases, small-molecule β-lactamase inhibitors are often co-administrated with β-lactam antibiotics to inactivate β-lactamases, thus protecting the antibiotics from the hydrolysis by β-lactamases. Augmentin (amoxillicin and clavulanic acid) and AVYCAZ® (ceftazidime and avibactam) are two examples of the formulation of β-lactam antibiotic/inhibitor used in the current clinical settings (Stein and Gurwith 1984; Zhanel et al. 2013) . With the rapid emergence of β-lactamase-mediated antibiotic resistance, there is a pressing need to identify novel β-lactamase inhibitors, either natural or synthetic compounds, to restore the efficacy of the β-lactam antibiotics that are susceptible to the hydrolytic action of the newly emerged β-lactamases (Meziane-Cherif and Courvalin 2014) . Regarding the inhibitory effect of BLIP on clinically prominent class A β-lactamases, BLIP has a high potentiality to become a protein drug that is co-formulated with β-lactam antibiotics in order to allow effective treatment strategy for bacterial infections. Attempts have been made to develop peptide drugs derived from the critical components of BLIP that are involved in the binding to TEM-1 β-lactamase for the inactivation of β-lactamases (Rudgers et al. 2001; Rudgers and Palzkill 2001; Sun et al. 2005; Alaybeyoglu et  al. 2015, 2017) . In addition, it is envisioned that by mutating BLIP, BLIP may turn into a tight binder to other classes of β-lactamases, effectively inactivating these β-lactamases (Strynadka et  al. 1996; Huang et al. 1998; Rudgers and Palzkill 1999; Huang et al. 2000; Wang et  al. 2007; Yuan et  al. 2011; Chow et  al. 2016) . Third, the property of high-affinity binding of BLIP to TEM-1 β-lactamase has been recently adapted to a variety of biotechnological applications (Khait and Schreiber 2012; Banala et  al. 2013; Janssen et  al. 2015; Hu et  al. 2016) . In order to have sufficient amount of highly purified BLIP for the above purposes, it is important to have an efficient system for the production of BLIP. So far, various approaches have been reported to obtain BLIP (Table 1). Extraction of BLIP from its native host S. clavuligerus and heterologous expression of BLIP using another Streptomyces species, S. lividian, gave a limited quantity of BLIP (Doran et al. 1990; Paradkar et al. 1994) , suggesting that Streptomyces may not be optimal for over-producing BLIP. Production of BLIP as a heterologous recombinant protein in the well-established E. coli expression system has been reported to allow improved yield of BLIP (~ 0.25  mg to ~ 4.2  mg/L culture of BLIP) (Albeck and Schreiber 1999; Petrosino et  al. 1999; Rudgers and Palzkill 1999; Reyonlds et al. 2006; Hu et al. 2016) . The high expression level of recombinant BLIP in E. coli might be due to the high copy number of expression plasmid and the use of strong promoter for inducing protein expression. In addition, production of BLIP as a histidinetagged protein in E. coli greatly simplified the subsequent purification strategy, minimizing the protein loss resulted from multiple steps of purification (Petrosino et al. 1999; Hu et  al. 2016) . However, BLIP formed inclusion bodies when being expressed in E. coli and this required the use of denaturing agents (e.g. urea) to solubilize the inclusion bodies prior to purification (Albeck and Schreiber 1999; Hu et  al. 2016) . To circumvent this constrain, addition of signal peptide sequence into the upstream of the blip gene in the expression construct was employed to direct the translated BLIP protein into the periplasmic space of E. coli (Petrosino et  al. 1999; Reyonlds et  al. 2006) . Furthermore, the strategy of expressing BLIP in a secretory fashion in B. subtilis, which yielded ~ 3.5 mg/L culture of BLIP, was developed (Liu et al. 2004). In this study, we devised a secretory expression system in Pichia pastoris for high-level production of BLIP. P. pastoris is a methylotrophic yeast which utilizes methanol (MeOH) as a sole carbon source. It has been an expression host optimized for high-level expression for foreign proteins in either the intracellular or secretory modes (Cereghino and Cregg 2000; Ahmad et  al. 2014; Krainer et  al. 2016) . Here, we subcloned the blip gene from S. clavuligerus to a commercially available plasmid pPICZαA for secretory protein expression in P. pastoris. Our results demonstrate that under the control of methanol-inducible promoter of the alcohol oxidase 1 (AOX1) gene and signal peptide processing of the translated protein, BLIP can be successfully expressed in P. pastoris in a secretory manner. Unprecedentedly large amount of ~ 300  mg BLIP with high purity was obtained directly from the supernatant of 1 L culture (Table 1). The recombinant BLIP was functionally active and showed same Ki as the native BLIP isolated from S. clavuligerus did. Furthermore, the Pichia-produced BLIP enhanced the bacteria killing efficiency of ampicillin (a penicillin-type of β-lactam antibiotic) in β-lactamase-producing Grampositive B. subtilis. Materials and methods Bacterial strains, plasmids and chemicals Streptomyces clavuligerus (ATCC 27064) was purchased from ATCC (Manassas, VA, USA). E. coli XL1-Blue for transformation was obtained from lab stock. P. pastoris X-33 and plasmid pPICZαA were obtained from Invitrogen (Carlsbad, CA, USA). B. subtilis 168 haboring plasmid pYCL18 and E. coli haboring pRSET-K/TEM-1 β-lactamase were from lab stock. Ampicillin and chloramphenicol were purchased from Sigma (St. Louis, MO, USA) whereas Zeocin was from Invitrogen (Carlsbad, CA, USA). Preparation of chromosomal DNA from S. clavuligerus Streptomyces clavuligerus was streaked on a nutrient agar plate. A single colony of S. clavuligerus was inoculated to a 5  mL of LB medium and cultivated at 30  °C with shaking for 2–3  days. Chromosomal DNA from S. clavuligerus was extracted from 1  mL of the inoculum by Wizard Genomic DNA purification kit (Promega, Madison, WI, USA) according to manufacturer’s manual (Technical Manual No. 050, Promega). Subcloning of blip gene into expression plasmid pPICZαA Amplification of blip gene (Accession Number: AAA16182) by polymerase chain reaction was performed by iProof DNA polymerase (Bio-Rad, Hercules, CA, USA) using the chromosomal DNA from S. clavuligerus as a template. A forward primer (5′-gat ata GAA TTC gcg ggg gtg atg acc ggg gcg-3′) and a reverse primer (5′ gat ata TCT AGA ggt cga ctc ctt cgg cga cg-3′), containing EcoRI and XbaI sites (bolded) respectively, were employed to amplify the sequence of the blip gene encoding the mature protein with its transcription terminator. The amplified PCR product was digested by EcoRI and XbaI and then ligated with an EcoRI-XbaI double digested pPICZαA. The ligation mixture was transformed into E. coli XL1-Blue and the transformants were selected on low salt LB agar plates containing 25  μg/mL Zeocin. The resultant plasmid was designated as pPICZαA/BLIP. the induction. The expression and purity of BLIP were assessed by SDS-PAGE analysis whereas total protein concentration was determined by Bradford assay. Transformation of expression plasmid into P. pastoris Plasmid pPICZαA/BLIP was transformed into P. pastoris by the method of electroporation. Briefly, plasmid pPICZαA/BLIP was first digested by SacI for linearization to promote the integration of the blip gene into the chromosome of P. pastoris via homologous recombination. Then 5–10  μg of linearized plasmid was mixed with the competent cells of P. pastoris X-33 (prepared as described in the manufacturer’s manual) in an electroporation cuvette and incubated on ice for 5 min. Electroporation was performed by using Gene Pulser II (Bio-Rad, Hercules, CA, USA), with a setting of 1.5 kV with 200 Ω, 25 μF capacitance, and a pulse time of 5–7 ms. Afterward, 1  mL of ice-cold 1  M sorbitol was added to the cuvette immediately. The mixture was then transferred to several sterile eppendorf tubes, which were incubated at 30  °C for 1.5 h. After that, it was centrifuged at 3000g for 1 min. Supernatant was removed and the cells were resuspended in a 200 µL of 1 M sorbitol solution. The cells were then plated on YPD agar plates containing 100 µg/mL Zeocin and incubated at 30 °C for 3 days. Several single colonies were picked from the plate and then streaked on a fresh YPD agar plate containing 800 µg/mL Zeocin for further selection for the multi-copy recombinants. Over‑expression of recombinant BLIP in P. pastoris A single colony of recombinant P. pastoris X-33 integrated with blip gene was inoculated in 5  mL of YPD medium with 100 μg/mL Zeocin and incubated at 30 °C with 250  rpm agitation for 20  h. A 0.5  mL of the overnight culture was then used to inoculate a 100  mL of BMGY (100  mM potassium phosphate, pH 6.0; 1.34% YNB; 4 × 10−5% biotin; 1% glycerol; 1% yeast extract; 2% peptone) in a 1  L-flask. The cells were incubated at 30 °C with a 250 rpm agitation and grown for 20 h. When OD600 reached more than 5.0, the cells were pelleted by centrifugation for 10  min at 3000g, 4  °C. The cells were then resuspended with a 20  mL of BMMY (100  mM potassium phosphate, pH 6.0; 1.34% YNB; 4 × 10−5% biotin; 1% yeast extract; 2% peptone) supplemented with 2% MeOH to allow methanol-induced protein expression. The culture was incubated at 30 °C with a 250 rpm agitation for 72 h. A 2% MeOH was added to the culture every 24  h so as to provide the carbon source and maintain ESI–MS analysis Prior to ESI–MS, the BLIP sample was desalted with Milli-Q water by an Amicon Ultra-4 centrifugal filter device (cut-off = 10,000  Da; Millipore, Bedford, MA, USA). A 10  ρmol/μL of BLIP solution in 1:1 (v/v) water-acetonitrile with 15% ammonium hydroxide was then prepared for ESI–MS. The ESI mass spectrum was obtained in the negative ion mode with a quadrupole time of flight (Q-Tof 2, Micromass, Altrincham, UK) mass spectrometer equipped with a Z-spray electrospray ionization source. Masslynx software version 4.1 was used as an operating interface for the instrument. The ESI-Q-TOF MS operating parameters were optimized and set as follows: ESI capillary voltage, 2000–3000  V; sample cone voltage, 30–50 V; source temperature, 80 °C; desolvation temperature, 150  °C; flow-rate of desolvation gas (N2), 350 L/h; flow-rate of cone gas (N2), 50 L/h. The m/z range of 500–3000 was monitored. The instrument was calibrated with a 10 ρmol/μL of horse heart myoglobin [in a 1:1 water-acetonitrile mixture (v/v)]. BLIP was assumed to be represented by a series of peaks corresponding to multiply protonated ions in the mass spectrum. This multiply charged mass spectrum was processed by a transform program to obtain the molecular mass of BLIP. Ki determination The Ki value for the BLIP against TEM-1 β-lactamase was determined using the method described by Petrosino et al. (1999). Procedure for the production of TEM-1 β-lactamase was mentioned in Additional file 1: Methods. 1.5 nM TEM-1 β-lactamase was pre-incubated with varying concentrations of BLIP (0–15 nM) in 50 mM sodium phosphate buffer containing 1  mg/mL bovine serum albumin for 2  h at 25  °C. Nitrocefin was then added to the mixture of BLIP-TEM1 β-lactamase at a final concentration of 21  μM. Hydrolysis of nitrocefin was monitored by the increase in absorbance at the wavelength at 500 nm. The equilibrium dissociation constant (Ki*) was calculated by fitting the plot of the concentrations of free β-lactamase versus concentrations of inhibitor (BLIP) with a nonlinear regression equation (Eq.  1) using the program OriginPro 6.0 (OriginLab Corporation). Efree = [E0] − [E0] + [I0] + Ki ∗ − ([E0] + [I0] + Ki∗)2 − (4[E0][I0]) (1) where [Efree] is the concentration of free β-lactamase, [E0] is the initial β-lactamase concentration, and [I0] is the initial inhibitor (BLIP) concentration. Ki* is equivalent to Ki, which is the inhibition constant (Petrosino et al. 1999) . In vitro β‑lactamase inhibitory assay Bacillus subtilis haboring pYCL18 that constitutively coexpresses PenP and PenPC β-lactamases was cultivated in 5  mL of LB broth at 37  °C with agitation at 280  rpm. When OD600 reached 3.0, a 5 μL of the culture was transferred to a fresh 5 mL of LB broth with different composition of BLIP and ampicillin. The inoculums were allowed to grow at 37  °C with agitation at 280  rpm. Cell growth was monitored by measuring OD600 of the cell culture at different time intervals. Results Recombinant BLIP was over‑expressed as a secretory protein in P. pastoris To construct the recombinant yeast strain for expression of BLIP, an expression vector was constructed by inserting the blip gene and its terminator sequence from S. clavuligerus into the pPICZαA at the region downstream the AOX1 promoter and α-factor mating signal sequence (Fig.  1a, b). The resultant plasmid pPICZαA/BLIP was then SacI-linearized and transformed into P. pastoris X-33. During transformation, the blip gene was integrated into the Pichia genome via homologous recombinant at AOX1 locus either as a single copy or multiple copies (Fig. 2). Integrants were then selected with Zeocin. The selected recombinant Pichia integrant was ready for heterologous expression for BLIP. Recombinant P. pastoris cells with blip gene were first cultivated in BMGY medium for 20  h. To induce the expression of the target protein (BLIP), the cells were collected and transferred to BMMY containing 2% MeOH and then allowed to grow for further 72  h. According to our data, there was no BLIP detected in the culture medium before the methanol-induction, indicating that the expression of BLIP was tightly controlled by the AOX1 promoter in P. pastoris (Fig.  3a). Secretory BLIP was found in the culture supernatants collected at 24, 48 and 72  h after methanol-induction. Approximately 300 mg of > 90% pure BLIP/L culture was, in total, recovered from the culture supernatant. The secretory BLIP obtained from the culture of P. pastoris was analyzed by ESI–MS (Fig.  3b). The measured mass of BLIP was 18219, which corresponds to the calculated mass of mature BLIP with a peptide of EAEAEF at its N-terminus (18,219.25). The results suggest that the part of the signal peptide of the pro-protein of P. pastoris-expressed BLIP was cleaved at the site between Arg and Glu by the aminopeptidase Kex2 protease to release the EAEAEF-mature BLIP and further trimming of the amino-terminal Glu-Ala residue repeats by the STE13 gene product did not occur (Fig. 1b). P. pastoris‑expressed BLIP showed tight binding with TEM‑1 β‑lactamases To assess the binding ability of the P. pastoris-expressed BLIP to TEM-1 β-lactamase, the inhibition constant (Ki) value of BLIP on TEM-1 β-lactamase was evaluated. Recombinant BLIP expressed in P. pastoris exhibited a Ki of 0.55  nM (Fig.  4). This Ki value was comparable to the reported Ki value (0.5 nM) of the native BLIP from S. clavuligerus. This indicated that the secreted BLIP from P. pastoris was correctly folded and showed similar performance as the S. clavuligerus-expressed BLIP in term of the association with TEM-1 β-lactamase. Co‑administration of ampicillin with BLIP inhibited growth of β‑lactamases‑producing B. subtilis To test the β-lactamase inhibitory effect of BLIP on bacterial growth, BLIP was added to the culture of a genetically modified Gram-positive B. subtilis strain (B. subtilis/ pYCL18) that constitutively secretes PenP and PenPC β-lactamases (Gray and Chang 1981; Madgwick and Waley 1987) . B. subtilis/pYCL18 can grow in the LB broth supplemented with 100  μg/mL ampicillin owing to the resistance conferred by β-lactamases (Fig. 5). Apart from this, the strain of B. subtilis/pYCL18 is also resistant to chloramphenicol due to the presence of a chloramphenicol acetyltransferase (cat) gene in pYCL18 (Additional file 1: Figure S1). BLIP itself has no bacterial killing effect and showed no inhibitory effect on bacterial growth in our preliminary study (data not shown). Addition of (See figure on next page.) Fig. 1 Expression construct pPICZαA/BLIP for production of secretory BLIP in P. pastoris. a Plasmid map of pPICZαA/BLIP (AOX1 promoter alcohol oxidase 1 promoter that permits the methanol‑inducible expression of BLIP in Pichia, BLIP terminator blip transcription terminator that allows 3′mRNA processing of blip gene, TEF1 promoter and EM7 promoter transcription elongation factor 1 gene from Saccharomyces cerevisiae and a synthetic prokaryotic promoter that drive the expression of the Zeocin resistance gene, Zeocin resistance marker Sh ble gene1 whose product confers resist‑ ance to Zeocin in Pichia cells for selection, CYC terminator 3′ end of the Saccharomyces cerevisiae cytochrome c1 gene that allows efficient 3′ mRNA processing of the Zeocin resistance gene, ori origin of replication); b Sequence that encodes the mature protein of BLIP was placed downstream the AOX1 promoter and α‑factor mating signal sequence (sequence encoding mature BLIP and the blip transcription terminator were shaded; Eco RI and XbaI restriction sites were underlined; Kex2 and Ste13 signal cleavage sites were indicated by arrow head and arrow respectively) 2.5 μM BLIP with 100 μg/mL ampicillin exerted an antimicrobial effect in which cannot be observed from the cultures that were added with either 2.5 μM BLIP only or 2.5 μM BLIP with 5 μg/mL chloramphenicol (Fig. 5). Discussion Considering the tight interaction between BLIP and various class A β-lactamases, BLIP is an intriguing protein not only having its importance as a study model for protein–protein interaction but also showing its potential applications in biopharmaceutical industry and biotechnology. To fulfill the needs for sufficient supply of BLIP for various purposes, it is necessary to develop highly productive system to obtain BLIP. Our study illustrated the first time to make use of P. pastoris as an expression platform for producing secretory BLIP. We attempted to develop the P. pastoris-based production system for BLIP based on several reasons. First, P. pastoris has been well characterized and developed for heterologous protein expression (Cereghino and Cregg 2000; Ahmad et al. 2014) . Easy genetic manipulation in P. pastoris favors the genetic modification of BLIP for research and biotechnological purposes. Second, P. pastoris has demonstrated its powerful capability to produce high level of correctly folded foreign proteins extracellularly (Cereghino and Cregg 2000; Ahmad et al. 2014) . In addition, blip gene has a high GC-content (66%) (Doran et  al. 1990) . The high GC content of blip gene may contribute to the formation of secondary structure in the mRNA during transcription, which subsequently interrupts the translation process, leading to a low expression level of BLIP. Taken the factor of GC content into consideration, P. pastoris may be a favorable expression host for proteins encoded by GC rich gene (Daly and Hearn 2005) as suggested by several cases of high level expression of foreign genes with enriched GC content in P. pastoris (Clare et al. 1991; Olsen et al. 1996; Tull et al. 2001) . Taken together, it was speculated that a high level of secretory BLIP expression might be achieved in the Pichia expression system. Third, regarding the potentiality of BLIP to be a biopharmaceutical, P. pastoris is well suited for producing BLIP for pharmaceutical use because P. pastoris is generally recognized as safe and various P. pastoris-expressed biopharmaceutical proteins have gained FDA approval (Çelik and Çalık 2012; Berlec and Strukelj 2013; Gonçalves et al. 2013; Meehl and Stadheim 2014) . From our results, a high titer of ~ 300 mg/L culture of secreted BLIP was achieved in P. pastoris. The recombinant BLIP was found to be highly pure (> 90%) in the culture medium and could be easily recovered by clarifying the culture medium by centrifugation. Compared with other approaches that utilize E. coli and B. subtilis expression system, giving several milligrams per L culture of BLIP (Albeck and Schreiber 1999; Petrosino et al. 1999; Reyonlds et al. 2006; Liu et al. 2004; Hu et al. 2016) , our approach using Pichia for producing secretory BLIP showed a remarkable enhancement in the production yield of pure BLIP. In addition, secretory BLIP can be recovered directly from the culture supernatant, facilitating the downstream process for obtaining BLIP. Furthermore, since P. pastoris is favorable for fermentative growth due to capability to grow at high cell density (Olsen et  al. 1996) , the current system can be scale-up by fermentation to meet greater demands. The efficient production system of secretory BLIP using P. pastoris will be able to provide a promising supply of pure BLIP in large quantity, undoubtedly facilitating the study of BLIP and also the application of BLIP in pharmaceutical industry and biotechnology. Additional file Additional file 1. Abbreviations BLIP: β‑lactamase inhibitory protein; K i: inhibition constant; h: hour; min: minute; s: second; rpm: revolution per minute. Authors’ contributions KYW, KPH and YCL designed research; KHL, YKW, MST and PYL performed research; KHL, MWT, KPH and YCL analyzed data and wrote the paper. All authors read and approved the final manuscript. Author details 1 Department of Applied Biology and Chemical Technology and the State Key Laboratory of Chirosciences, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong, China. 2 Lo Ka Chung Centre for Natural Anti‑Cancer Drug Development, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong, China. Acknowledgements The authors thank Dr. Pui‑Kin So for his help and expertise in the mass spec‑ trometric analysis. Competing interests The authors declare that they have no competing interests. Availability of data and materials Data can be shared. Please send email to thomas.yun‑ chung.leung@polyu. edu.hk. Consent for publication Not applicable. Ethics approval and consent to participate Not applicable. This article does not contain any studies with human partici‑ pants or animals performed by any of the authors. Funding This study was funded by the Research Grants Council of the Hong Kong SAR (PolyU 5380/04M, 5402/06M and 5619/07M), the Hong Kong UGC Areas of Excellence Fund (Project No. AoE P/10‑01), and The Hong Kong Polytechnic University. All authors declare that there is no role of the funding body in the design of the study and collection, analysis, and interpretation of data and in writing the manuscript. Publisher’s Note Springer Nature remains neutral with regard to jurisdictional claims in pub‑ lished maps and institutional affiliations. Ahmad M , Hirz M , Pichler H , Schwab H ( 2014 ) Protein expression in Pichia pastoris: recent achievements and perspectives for heterologous protein production . Appl Microbiol Biotechnol 98 : 5301 - 5317 . https://doi. org/10.1007/s00253‑014‑5732‑5 Alaybeyoglu B , Akbulut BS , Ozkirimli E ( 2015 ) A novel chimeric peptide with antimicrobial activity . J Pept Sci 21 : 294 - 301 . https://doi.org/10.1002/ psc.2739 Alaybeyoglu B , Uluocak BG , Akbulut BS , Ozkirimli E ( 2017 ) The effect of a betalactamase inhibitor peptide on bacterial membrane structure and integrity: a comparative study . J Pept Sci . https://doi.org/10.1002/psc.2986 Albeck S , Schreiber G ( 1999 ) Biophysical characterization of the interaction of the β‑lactamase TEM ‑1 with its protein inhibitor BLIP . Biochemistry 38 : 11 - 21 . https://doi.org/10.1021/bi981772z Banala S , Aper SJ , Schalk W , Merkx M ( 2013 ) Switchable reporter enzymes based on mutually exclusive domain interactions allow antibody detection directly in solution . ACS Chem Biol 8 : 2127 - 2132 . https://doi. org/10.1021/cb400406x Berlec A , Strukelj B ( 2013 ) Current state and recent advances in biopharmaceutical production in Escherichia coli, yeasts and mammalian cells . J Ind Microbiol Biotechnol 40 : 257 - 274 . https://doi.org/10.1007/ s10295‑013‑1235‑0 Çelik E , Çalık P ( 2012 ) Production of recombinant proteins by yeast cells . Biotechnol Adv 30 : 1108 - 1118 . https://doi.org/10.1016/j. biotechadv. 2011 . 09 .011 Cereghino JL , Cregg JM ( 2000 ) Heterologous protein expression in the methyltrophic yeast Pichia pastoris . FEMS Microbiol Rev 24 : 45 - 66 . https://doi. org/10.1111/j.1574‑ 6979 . 2000 .tb00532.x Chow DC , Rice K , Huang W , Atmar RL , Palzkill T ( 2016 ) Engineering specificity from broad to narrow: design of a β‑lactamase inhibitory protein (BLIP) variant that exclusively binds and detects KPC β‑lactamase . ACS Infect Dis 2 : 969 - 979 . https://doi.org/10.1021/acsinfecdis.6b00160 Clare JJ , Rayment FB , Ballantine SP , Sreekrishna K , Romanos MA ( 1991 ) Highlevel expression of tetanus toxin fragment C in Pichia pastoris strains containing multiple tandem integrations of the gene . Biotechnology (NY) 9 : 455 - 460 . https://doi.org/10.1038/nbt0591‑ 455 Cohen‑Khait R , Schreiber G ( 2016 ) Low‑stringency selection of TEM1 for BLIP shows interface plasticity and selection for faster binders . Proc Natl Acad Sci USA 113 : 14982 - 14987 . https://doi.org/10.1073/pnas.1613122113 Daly R , Hearn MT ( 2005 ) Expression of heterologous proteins in Pichia pastoris: a useful experimental tool in protein engineering and production . J Mol Recognit 18 : 119 - 138 . https://doi.org/10.1002/jmr.687 Doran JL , Leskiw BK , Aippersbach S , Jensen SE ( 1990 ) Isolation and characterization of a β‑lactamase ‑inhibitory protein from Streptomyces clavuligerus and cloning and analysis of the corresponding gene . J Bacteriol 172 : 4909 - 4918 . https://doi.org/10.1128/jb.172.9. 4909 ‑ 4918 . 1990 Gonçalves AM , Pedro AQ , Maia C , Sousa F , Queiroz JA , Passarinha LA ( 2013 ) Pichia pastoris: a recombinant microfactory for antibodies and human membrane proteins . J Microbiol Biotechnol 23 : 587 - 601 . https://doi. org/10.4014/jmb.1210.10063 Gray O , Chang S ( 1981 ) Molecular cloning and expression of Bacillus licheniformis β‑lactamase gene in Escherichia coli and Bacillus subtilis . J Bacteriol 145 : 422 - 428 Hu R , Yap HK , Fung YH , Wang Y , Cheong WL , So LY , Tsang CS , Lee LY , Lo WK , Yuan J , Sun N , Leung YC , Yang G , Wong KY ( 2016 ) “ Light up” proteinprotein interaction through bioorthogonal incorporation of a turn‑ on fluorescent probe into β‑lactamase . Mol BioSyst 12 : 3544 - 3549 . https:// doi.org/10.1039/c6mb00566q Huang W , Petrosino J , Palzkill T ( 1998 ) Display of functional β‑lactamase inhibitory protein on the surface of M13 bacteriophage . Antimicrob Agents Chemother 42 : 2893 - 2897 Huang W , Zhang Z , Palzkill T ( 2000 ) Design of potent β‑lactamase inhibitors by phage display of β‑lactamase inhibitory protein . J Biol Chem 275 : 14964 - 14968 . https://doi.org/10.1074/jbc.M001285200 Janssen BM , Engelen W , Merkx M ( 2015 ) DNA‑ directed control of enzymeinhibitor complex formation: a modular approach to reversibly switch enzyme activity . ACS Synth Biol 4 : 547 - 553 . https://doi.org/10.1021/ sb500278z Khait R , Schreiber G ( 2012 ) FRETex: a FRET‑based, high‑throughput technique to analyze protein-protein interactions . Protein Eng Des Sel 25 : 681 - 687 . https://doi.org/10.1093/protein/gzs067 Kozer N , Kuttner YY , Haran G , Schreiber G ( 2007 ) Protein-protein association in polymer solutions: from dilute to semidilute to concentrated . Biophys J 92 : 2139 - 2149 . https://doi.org/10.1529/biophysj.106.097717 Krainer FW , Gerstmann MA , Damhofer B , Birner‑ Gruenberger R , Glieder A ( 2016 ) Biotechnological advances towards an enhanced peroxidase production in Pichia pastoris . J Biotechnol 233 : 181 - 189 . https://doi. org/10.1016/j.jbiotec. 2016 . 07 .012 Liu HB , Chui KS , Chan CL , Tsang CW , Leung YC ( 2004 ) An efficient heat‑inducible Bacillus subtilis bacteriophage φ105 expression and secretion system for the production of the Streptomyces clavuligerus β‑lactamase inhibitory protein (BLIP) . J Biotechnol 108 : 207 - 217 . https://doi.org/10.1061/j. jbiotec. 2003 . 12 .004 Madgwick PJ , Waley SG ( 1987 ) β‑Lactamase I from Bacillus cereus: structure and site‑ directed mutagenesis . Biochem J 248 : 657 - 662 . https://doi. org/10.1042/bj2480657 Meehl MA , Stadheim TA ( 2014 ) Biopharmaceutical discovery and production in yeast . Curr Opin Biotechnol 30 : 120 - 127 . https://doi.org/10.1016/j. copbio. 2014 . 06 .007 Meziane‑ Cherif D , Courvalin P ( 2014 ) Antibiotic resistance: to the rescue of old drugs . Nature 510 : 477 - 478 . https://doi.org/10.1038/510477a Olsen O , Thomsen KK , Weber J , Duus JO , Svendsen I , Wegener C , von Wettstein D ( 1996 ) Transplanting two unique β‑ glucanase catalytic activities into one multi‑ enzyme, which forms glucose . Biotechnology (NY) 14 : 71 - 76 . https://doi.org/10.1038/nbt0196‑ 71 Paradkar AS , Petrich AK , Leskiw BK , Aidoo KA , Jensen SE ( 1994 ) Transcriptional analysis and heterologous expression of the gene encoding β‑lactamase inhibitor protein (BLIP) from Streptomyces clavuligerus . Gene 144 : 31 - 36 . https://doi.org/10.1016/ 0378 ‑ 1119 ( 94 ) 90199 ‑ 6 Petrosino J , Rudgers G , Gilbert H , Palzkill T ( 1999 ) Contributions of aspartate 49 and phenylalanine 142 residues of a tight binding inhibitory protein of β‑lactamase . J Biol Chem 274 : 2394 - 2400 . https://doi.org/10.1074/ jbc.274.4. 2394 Reyonlds KA , Thomson JM , Corbett KD , Bethel CR , Berger JM , Kirsch JF , Bonomo RA , Handel TM ( 2006 ) Structural and computational characterization of the SHV‑1 β‑lactamas‑β‑lactamase inhibitor protein interface . J Biol Chem 281 : 26745 - 26753 . https://doi.org/10.1074/jbc.M603878200 Rudgers GW , Palzkill T ( 1999 ) Identification of residues in β‑lactamase critical for binding β‑lactamase inhibitory protein . J Biol Chem 274 : 6963 - 6971 . https://doi.org/10.1074/jbc.274.11.6963 Rudgers GW , Palzkill T ( 2001 ) Protein minimization by random fragmentation and selection . Protein Eng 14 : 487 - 492 . https://doi.org/10.1093/ protein/14.7. 487 Rudgers GW , Huang W , Palzkill T ( 2001 ) Binding properties of a peptide derived from β‑lactamase inhibitory protein . Antimicrob Agents Chemother 45 : 3279 - 3286 . https://doi.org/10.1128/AAC.45.12. 3279 ‑ 3286 . 2001 Selzer T , Albeck S , Schreibier G ( 2000 ) Rational design of faster associating and tighter binding protein complexes . Nat Struct Biol 7 : 537 - 541 . https://doi. org/10.1038/76744 Stein GE , Gurwith MJ ( 1984 ) Amoxicillin-potassium clavulante, a β‑lactamase ‑ resistant antibiotic combination . Clin Pharm 3 : 591 - 599 Strynadka NC , Jensen SE , Johns K , Blanchard H , Page M , Matagne A , Frère JM , James MN ( 1994 ) Structural and kinetic characterization of a β‑lactamase ‑ inhibitor protein . Nature 368 : 657 - 660 . https://doi.org/10.1038/3686657a0 Strynadka NC , Jensen SE , Alzari PM , James MN ( 1996 ) A potent new mode of β‑lactamase inhibition revealed by the 1.7 Å X ‑rat crystallographic structure of the TEM‑1‑BLIP complex . Nat Struct Biol 3 : 290 - 297 . https:// doi.org/10.1038/nsb0396‑ 290 Sun W , Hu Y , Gong J , Zhu C , Zhu B ( 2005 ) Identification of β‑lactamase inhibitory peptide using yeast two‑hybrid system . Biochemistry (Mosc) 70 : 753 - 760 . https://doi.org/10.1007/s10541‑005‑0180‑6 Tull D , Gottschalk TE , Svendsen I , Kramhøft B , Phillipson BA , Bisqård‑Frantzen H , Olsen O , Svensson B ( 2001 ) Extensive N‑ glycosylation reduces the thermal stability of a recombinant alkalophilic Bacillus α‑amylase produced in Pichia pastoris . Protein Expr Purif 21 : 13 - 23 . https://doi.org/10.1006/ prep. 2000 .1348 Wang J , Zhang Z , Palzkill T , Chow DC ( 2007 ) Thermodynamic investigation of the role of the contact residues of β‑lactamase ‑inhibitory protein for binding to TEM‑1 β‑lactamase . J Biol Chem 282 : 17676 - 17684 . https://doi. org/10.1074/jbc.M611548200 Yuan J , Chow DC , Huang W , Palzkill T ( 2011 ) Identification of a β‑lactamase inhibitory protein variant that is a potent inhibitor of Staphylococcus PC1 β‑lactamase . J Mol Biol 406 : 730 - 744 . https://doi.org/10.1016/j. jmb. 2011 . 01 .014 Zhanel GG , Lawson CD , Adam H , Schweizer F , Zelenitsky S , Lagacé‑ Wiens PR , Denisuik A , Rubinstein E , Gin AS , Hoban DJ , Lynch JP 3rd, Karlowsky JA ( 2013 ) Ceftazidime‑avibactam: a novel cephalosporin/β‑lactamase inhibitor combination . Drugs 73 : 159 - 177 . https://doi.org/10.1007/ s40265‑013‑0013‑7 Zhang Z , Palzkill T ( 2003 ) Determinants of binding affinity and specificity for the interaction of TEM‑1 and SME‑1 β‑lactamase with β‑lactamase inhibitory protein . J Biol Chem 278 : 45706 - 45712 . https://doi.org/10.1074/jbc. M308572200


This is a preview of a remote PDF: https://link.springer.com/content/pdf/10.1186%2Fs13568-018-0586-3.pdf

Kin-Ho Law, Man-Wah Tsang, Yuk-Ki Wong, Ming-San Tsang, Pui-Yee Lau, Kwok-Yin Wong, Kwok-Ping Ho, Yun-Chung Leung. Efficient production of secretory Streptomyces clavuligerus β-lactamase inhibitory protein (BLIP) in Pichia pastoris, AMB Express, 2018, 64, DOI: 10.1186/s13568-018-0586-3